NEWS:    GM recalls 944,000 vehicles for fire hazard

Recall involves vehicles that are equipped with windshield washer fluid heaters.

NEW YORK (CNNMoney.com) -- August 28, 2008 -- General Motors is recalling 944,000 vehicles, 850,000 of them in the United States, because of the potential for a fire in the vehicles' heated windshield washer fluid system.

A short circuit in the circuit board that controls the system could cause a grounding wire to overheat. That could lead to smoke and the malfunctioning of other electrical components, GM (GM, Fortune 500) said in a letter to the National Highway Traffic Safety Administration (NHTSA). In rare cases, it could cause a fire, GM said.

GM is aware of three fires caused by this problem, two of which were in the company's own test fleet vehicles, GM spokesman Tom Wilkinson said. The company is not aware of any injuries caused by the problem.

The vehicles must be turned on for the short circuit to occur, Wilkinson said, but he could not say whether the washer fluid heating system needed to be in use.

The models listed below, if they're equipped with a heated windshield washer fluid system, are subject to the recall:

• Model year 2006-08 Buick Lucerne sedans and model year 2008 Buick Enclave SUVs.
• Model year 2006-08 Cadillac DTS sedans and model year 2007-08 Cadillac Escalade, Escalade ESV and Escalade EXT SUVs.
• Model year 2007-08 Chevrolet Avalanche and Silverado trucks and Suburban and Tahoe SUVs.
• Model year 2007-08 GMC Acadia, Yukon, and Yukon XL SUVs and Sierra trucks.
• 2008 Saturn Outlook SUVs.

The fluid heating system is a popular option on many of GM's large cars and SUVs, said Wilkinson.

On cold days, the system heats windshield washer fluid before spraying it onto the windshield, where it can melt ice and frost on the windshield.

To fix the problem, dealers will install a fuse that will shut off the system in the event of a short circuit. GM has not yet provided NHTSA with a schedule detailing when owners of affected vehicles will be notified.

MORE RECALL INFORMATION:

• Buick Lucerne
• Buick Enclave
• Cadillac DTS
• Cadillac Escalade
• Chevrolet Avalanche
• Chevrolet Silverado
• Chevrolet Suburban
• Chevrolet Tahoe
• GMC Acadia
• GMC Sierra
• GMC Yukon
• Saturn Outlook

---

AUGUST 2008 -- GM is recalling 857,735 MY 2006-2008 Buick Lucerne; Cadillac DTS; Hummer H2; MY 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT; Chevrolet Avalanche, Silverado, Suburban, Tahoe; GMC Acadia, Sierra, Yukon, Yukon XL, Saturn Outlook; and MY 2008 Buick Enclave vehicles equipped with a heated wiper washer fluid system. A short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire. This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire. Dealers will install a wire harness with an in-line fuse free of charge. The manufacturer has not yet provided an owner notification schedule.  08V441

NEWS:    NHTSA Investigates 2.7 Million GM Trucks, SUVs

Fire hazard probed in 21 models

ConsumerAffairs.com -- June 17, 2008 -- The National Highway Traffic Safety Administration (NHTSA) has intensified a investigation of 21 models of General Motors trucks and SUVS manufactured between 2006 and 2008 because of the possibility of an engine compartment fire.

More than 2,700,000 GM trucks and SUVs are the subject of the the investigation because of the possibility that a fire might erupt inside the engine compartment, even when the ignition is turned off.

The Office of Defects Investigation (ODI) at the federal safety agency reported that investigators are now aware of "41 non-crash engine compartment fires" in the GM trucks and SUVs including 8 fires that may have caused significant property damage.

The GM vehicles under investigation are:

• Cadillac Escalade ESV and EXT from the 2007 and 2008 model years
• Chevrolet Avalanche 1500 from the 2007 and 2008 model years
• 2007 Chevrolet Avalanche 2500
• 2007 Chevrolet Silverado
• Chevrolet Silverado 1500, 2500 and 3500 from the 2007 and 2008 model years
• Chevrolet Suburban 1500 and 2500 from the 2007 and 2008 model years
• Chevrolet Tahoe from the 2007 and 2008 models year
• 2008 GMC Sierra,
• GMC Sierra 1500, 2500 and 3500 from the 2007 and 2008 model years
• 2007 GMC Sierra Classic
• 2007 GMC Silverado, GMC Yukon from the 2007 and 2008 model years
• GMC Yukon XL 1500, XL 2500 from the 2007 and 2008 model years
• Hummer H2 from the 2006 to 2007 model years
• 2008 Hummer H2 Utility, and •the Hummer H2 from the 2006 to 2008 model years

"GM provided ODI with 41 allegations of non-crash engine compartment fires including 16 allegations of fires origination with the ignition in the off position," according to the NHTSA Web site.

Investigators are examining the electrical system, engine and engine cooling system; battery cables; under-hood wiring, fuses and circuit breakers.

NHTSA investigator are now call the probe an "engineering analysis" which could eventually lead to a recall of the General Motors trucks and SUVs.

MORE RECALL INFORMATION:

• Cadillac Escalade

• Chevrolet Avalanche

• Chevrolet Silverado

• Chevrolet Suburban

• Chevrolet Tahoe

• GMC Sierra

• GMC Yukon

• Hummer H2

NEWS:    Feds Probe Fire Complaints in Chevy Tahoe, GMC Yukon

ConsumerAffairs.Com -- February 9, 2008 --  The National Highway Traffic Safety Administration (NHTSA) is investigating two consumer complaints that 2007 Chevrolet Tahoes and GMC Yukons caught fire while parked in home garages with the engines off.

The truck owners reported to NHTSA that both homes were badly damaged and two people were injured in one of the fires.

The NHTSA Office of Defect Investigations as open a preliminary investigation of both vehicles that could eventually lead to a recall of the SUVs. The agency estimates as many as 400,000 vehicles would be affected if a defect is identified and a recall ordered.

The General Motors SUVs are not equipped with the type of cruise control system that causes a fire in Ford Motor Co. cars and trucks. Ford has recalled more than 10 million vehicles because of a fire danger.

NHTSA also reported on its web site that a preliminary investigation is under way of 2006 Lamborghini Gallardos following three reports of fires. There are 600 of the Gallardos cars on U.S. roads.

More Recall Information:   GMC Yukon  -   Chevy Tahoe

NOVEMBER 2007 -- GM is recalling 11,975 MY 2001 Chevrolet Silverado and GMC Sierra pickup trucks equipped with an 8.1L V8 engine. The crankshaft position can operate intermittently or fail completely. If the sensor operates intermittently, the SES light may illuminate and the vehicle may run rough. The engine may stall, and if so, may re-start immediately or after a cool down period. If the sensor becomes completely inoperative, the engine will quit running and will not re-start. Either of these failures can increase the risk of a crash. Dealers will replace the crankshaft position sensor. The recall is expected to begin during December 2007. This recall was the subject of an Engineering Analysis, EA06-016, conducted by the Office of Defects Investigation. 07V521

NEWS:   Fire Hazard Prompts Big GM Truck and SUV Recall

ConsumerAffairs.Com  --  August 10, 2006  --  The National Highway Traffic Safety Administration is ordering the recall of 38,439 General Motors SUVs and pickups because of a potential fuel leak that could result in an engine compartment fire.

• GM is recalling the
  • 2004 Chevrolet Avalanche
  • 2004-2006 Chevrolet Avalanche 1500
  • 2006 Chevrolet Kodiak
  • 2004-2006 Chevrolet Silverado
  • 2004-2005 Chevrolet Suburban
  • 2006 Chevrolet Suburban 1500
  • 2004-2006 GMC Sierra
  • 2006 GMC Topkick 6500
  • 2004-2006 GMC Yukon XL

NHTSA reports that some of the GM trucks equipped with the 8.1 liter V8 contain a fuel rail pulse damper retainer clip that can fracture resulting in a fuel leak which is near an ignition source in the engine compartment.

NEWS:  GM to recall 553,00 SUVs, trucks to fix brakes.....

DETROIT, Dec 23 (Reuters) - General Motors Corp..said on Friday it is expanding an earlier recall of sport utility vehicles and pickup trucks to include another 553,000 vehicles because of potential problems with brakes. 

The recall is being expanded to include Delaware, Iowa, Maryland, Minnesota, Missouri, Wisconsin and the District of Columbia.

Vehicles affected by the recall include the Chevrolet Avalanche and Silverado pickups and the Chevrolet Suburban and Tahoe SUVs. The GMC Sierra pickup and Yukon and Yukon XL SUVs are also affected. All the vehicles are from the 1999-2002 model years.

NEWS:  October 7, 2005 --  ConsumerAffairs.com

Automakers are recalling 450,000 vehicles, including the Chevrolet Corvette, for a range of defects reported by the National Highway Traffic Safety Administration (NHTSA).

The General Motors recall includes 123,592 pickup trucks, SUVs, vans and cars because of potential power steering problems that could lead to engine fires. NHTSA reports that under extreme steering conditions the power steering hose may break and leak fluid. Power steering fluid could then spray onto hot engine parts and an engine compartment fire could occur.

NEWS: 

• Detroit Free Press - Customers knock GM on noisy engines.....

• Detroit Free Press (4/24/05) - General Motors Corp. is recalling more than 2 million vehicles...

• Detroit Free Press (2/10/05) - GM Recalls Nearly 200,000 Vehicles for various defects....

• Yahoo News - GM Recalls Nearly 200,000 Vehicles ....

• NHTSA - National Highway Traffic Safety Administration ....