SEPTEMBER 2007 -- VW is recalling 340,000 MY 2005-2008 Jetta and MY 2006-2008 Rabbit, GTI, and R32 vehicles for failing to comply with the requirements of Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment." Some vehicles may not have had a required cap installed which disables the headlight horizontal aim and some vehicles may contain a cap that disables the vertical aiming screw. Noncompliance can inhibit proper headlamp aim adjustment for roadway illumination. Improperly aimed headlamps could cause reduced road visibility, increasing the risk of a crash. Dealers will inspect for the presence of a cap in the socket of the low beam horizontal aiming screw and install one if missing, and inspect for the presence of a cap in the socket of the vertical aiming screw and if present, the cap will be removed. The recall is expected to begin on or about October 31, 2007. This recall was the subject of an investigation, OA-108-070412I, conducted by the Office of Vehicle Safety Compliance. 07V442

NEWS:   Volkswagen recalls Jetta cars over potential fuel leak

Detroit News -- July 8, 2007 -- Volkswagen AG is recalling 2006 Jetta cars with 2.5-liter gasoline engines in the United States because a tab on the windshield-wiper fluid container can rub against a fuel line, possibly causing a leak and fire, Bloomberg News reported.

The recall will affect about 58,900 cars and will begin in August, the National Highway Traffic Safety Administration said on its Web site. Dealers will remove the plastic tab on the fluid reservoir and, if necessary, replace the fuel line, Volkswagen told the agency, Bloomberg reported.

NEWS:   Volkswagen recalls nearly 800,000 cars

Defective brake lights on Golf, GTI, Jetta, New Beetle and R32 are a potential safety hazard and should be replaced.

February 26, 2007 - NEW YORK (CNNMoney.com) -- Around 800,000 Volkswagen vehicles have been recalled Monday because of faulty brake lights, the National Highway Traffic Safety Administration said.

The 790,000 vehicles include Jettas, New Beetles, Golfs, GTIs and R32s...all in the United States.

The specific years and models affected are:

• 1999-2005 Jetta sedans
• 2001-2005 Jetta wagons
• 1998-2007 New Beetle
• 2003-2007 New Beetle Convertibles
• 1999-2006 Golfs and GTIs
• 2004 R32

The malfunctioning brake lights and brake light switches could fail to come on or remain stuck on.

This recall expands on one announced by Europe's No. 1 carmaker last year, when 362,000 Jettas and New Beetles were recalled due to the same defective part.

Volkswagen said that dealers will immediately be prepared to accept service appointments to perform the repair at no charge, but the notification process isn't scheduled to begin until April.

NHTSA did not say if any injuries had been reported linked to the defective brake lights.

NEWS:   VW recalls 362,000 cars

May 26, 2006,  -- DETROIT (Reuters) - Volkswagen AG is recalling 362,000 cars in the United States because a brake light switch may malfunction, according to U.S. safety regulators.

The models involved include the Jetta sedan from 1999-2002 model years, Jetta III from 1999-2000 model years and the New Beetle from 1998-2002 model years, National Highway Traffic Safety Administration said on its Web site on Friday.

NEWS:   Volkswagen AG will recall 362,000 Jettas and New Beetles

May 26, 2006,  -- Volkswagen AG will recall 362,000 Jettas and New Beetles for brake-light failures, the NHTSA said.

The Volkswagen recall covers 1999 through 2002 Jettas and 1998 through 2002 New Beetles, the agency said. A brake-light switch may not have been properly installed during previous recalls in 2003 and 2004, and the lights either don't work or stay on all the time.

COMMON COMPLAINTS : 

• Check Engine Light on?

• Engine Coil

• Oxygen Sensor